|
| Assembly | Page |
|---|---|
| Running Gear Assembly | 2 |
| Cradle Assembly | 4 |
| Spool Assembly | 6-8 |
| Levelwind Assembly | 10 |
| Shut Off | 12 |
| Boom Lift | 14 |
| Shield Group | 16 |
| Turbine Assembly | 18-20 |
| Gearbox | 22 |
| Drive Train Group | 24 |
| Sprinkler Cart Assembly | 26 |
| Decal Group | 28 |
| Mechanical Engine Drive Assembly | 30 |
| Numerical Parts Listing | 32-40 |
Notes:
For Parts That Are Described As "Left" Or "Right" The Water Inlet Side Of The Machine Is Considered The Right Side.
Items Such As Common Fasteners, Grease Fitting, And Other Small Parts Easy To Acquire Locally Are Not Listed.
Page 3
| Running Gear Assembly | ||||
| No. | Part Number | Description | Qty. | |
| 1 | 526-5138-1 | Wheel, 6 Bolt 15" x 10KB | 2 | |
| 2 | 526-5531-0 | Tire, 11L x 15 12 Ply | 2 | |
| 3 | 588-0355-0 | Cap, Wilton 909902 Hub | 2 | |
| 3a | 589-0206-0 | Hub Cap Wilton 90903 | 2 | |
| 4 | 589-0207-0 | Nut, 7/8-14"NF Slotted Wilton 912952 | 2 | |
| 5 | 515-0939-0 | Bearing, Outer LM67048 | 2 | |
| 5a | 589-0204-0 | Bearing, Outer LM25877 | 2 | |
| 6a | 588-0250-3 | Hub, With Races Only, Wilton 280511 | 2 | |
| 6b | 588-0250-2 | Hub Assembly (Hub, Bearing & Races) | 2 | |
| 6c | 589-0199-0 | Hub, With Races Only, Wilton 280581 | 2 | |
| 6d | 226-1598-2 | Hub Assembly (Hub, Bearing & Races) | 2 | |
| 7 | 588-0355-4 | Bearing, Inner LM48548 | 2 | |
| 7b | 589-0203-0 | Bearing, Inner LM25590 | 2 | |
| 8 | 588-0355-3 | Seal, Grease CR15190 | 2 | |
| 8b | 589-0205-0 | Seal, Grease CR20148 | 2 | |
| 9 | 588-0355-5 | Bolt, Lug 1/2-NF | 12 | |
| 9b | 589-0202-0 | Bolt, Lug 9/16 Wilton 9135381 | 12 | |
| 10 | 500-0038-0 | Spindle | 2 | |
| 10b | 500-0566-0 | Spindle | 2 | |
| 10c | 500-0081-0 | Spindle | 2 | |
| 11 | 020-9963-6 | Bearing, Turntable | 1 | |
| 12 | 500-0046-0 | Chassis | 1 | |
| 12b | 500-0046-1 | Chassis | 1 | |
| 13 | 500-0023-1 | Jack Assembly | 1 | |
| 14 | 558-3281-1 | Pin, 3/4 x 4 1/8 Hitch | 2 | |
| 15 | 561-0204-0 | Hair Pin | 2 | |
| 16 | 523-5866-0 | Pin, 3/4 x 6 1/2 Hitch | 1 | |
| 17 | 595-0483-0 | Pin, Hitch 5.75" x 3/4" | 1 | |
| 19 | 589-0208-0 | Washer, Spindle Wilton 913607 | 2 | |
| 20 | 510-0940-0 | Race, Outer LM67010 | 2 | |
| 20b | 589-0201-0 | Race, Outer LM25821 | 2 | |
| 21 | 510-0940-1 | Race, Inner LM48510 | 2 | |
| 21b | 589-0200-0 | Race, Inner LM25520 | 2 |
Page 5
| Cradle Assembly | ||||
| No. | Part Number | Description | Qty. | |
| 1 | 022-0159-0 | Brake Control Screw | 1 | |
| 2 | 022-0156-0 | Hitrel Washer | 2 | |
| 3 | 022-0527-0 | Brkt. Brake Mt. | 1 | |
| 4 | 022-0160-1 | Pin, Brake | 2 | |
| 5 | 022-0158-1 | Brake Plate | 1 | |
| 6 | 022-0454-0 | Slide, (Brake Pad) | 2 | |
| 7 | 022-0157-1 | Brake Plate, Threaded | 1 | |
| 8 | 553-2413-0 | Washer, 3/4 Flat USS | 4 | |
| 9 | 020-1041-0 | Roller, Horizontal (D2) & (A1) | 1 | |
| 10A | 022-0027-0 | Stabilizer Foot, Left | 1 | |
| 10B | 022-0028-0 | Stabilizer Foot, Right | 1 | |
| 11 | 022-0576-0 | Pin, | 2 | |
| 12 | 020-9904-8 | Handle | 2 | |
| 13 | 020-9957-8 | Crank, 30 | 2 | |
| 14 | 020-1012-7 | Pawl | 2 | |
| 15 | 020-1012-8 | Spring Right | 1 | |
| 16 | 020-1013-5 | Spring Left | 1 | |
| 17 | 020-9905-6 | Bushing | 2 | |
| 18 | 020-9905-9 | Spring, Rubber | 2 | |
| 19 | 020-9904-9 | Washer, Plastic | 2 | |
| 20 | 020-9905-8 | Retainer Nut | 2 | |
| 21 | 020-1012-9 | Pin | 2 | |
| 22A | 022-0030-0 | Stabilizer Leg, Left | 1 | |
| 22B | 022-0029-0 | Stabilizer Leg, Right | 1 | |
| 23 | 550-7010-0 | Bolt, 8-1.25 X 20mm Brass ( Brake Pad) | 4 | |
| 28 | 597-0119-1 | Operator Manual Holder | 1 | |
| 28/A | 599-0064-0 | Operator Manual Bracket ( Not Shown ) | 1 | |
| 29 | 022-0479-0 | PTO Rewind Crank ( Not Shown ) | 1 |
Page 7
| Spool Assembly | ||||
| No. | Part Number | Description | Qty. | |
| 1 | 588-0023-3 | O-Ring 4" | 1 | |
| 2 | 022-0483-0 | Lower Feeder Pipe 3-1/2" | 1 | |
| 3 | 022-0484-0 | O-Ring 318mm OD x 3.53mm | 2 | |
| 4 | 022-0457-2 | Elbow, Upper | 1 | |
| 5 | 022-0039-0 | O-ring, 124mm x 3.53mm | 1 | |
| 6 | 022-0753-2 | Seal, Housing | 1 | |
| 7 | 022-0037-0 | Ring, Snap | 3 | |
| 8 | 022-0040-0 | Washer, Thrust | 1 | |
| 9 | 022-0038-0 | Spacer | 2 | |
| 10 | 020-9958-1 | Bearing, Spool | 1 | |
| 11 | 593-0245-1 | Ring Nut, Slip Joint | 1 | |
| 12 | 022-0032-0 | Bearing | 1 | |
| 13 | 596-0014-0 | Spacer | 1 | |
| 14 | 588-0256-1 | Hose End Outlet 4" | 1 | |
| 15 | 588-0023-1 | Lever Ring 4" 451 108mm | 1 | |
| 16 | 252-4962-0 | Hose, Irr. Supply 4" | FT. | 30 |
| 17A | 030-1924-0 | Clamp, Supra 104-112 (4" Hose) | 4 | |
| 18 | 588-0266-0 | Hose End Inlet 4" | 1 | |
| 18b | 593-0260-0 | End, Ringlock 4"x6" | 1 | |
| 19 | 400-4927-0 | Band, Ring 4" | 1 | |
| 19b | 400-4927-2 | Band, Ringlock 6" | 1 | |
| 20A | 022-0034-0 | Elbow, PE Tube 90mm | 1 | |
| 20B | 022-0127-0 | Elbow, PE Tube 100mm | 1 | |
| 21 | 022-0682-0 | Clamp, Hose Atlantic 86mm to 95mm | 4 | |
| 22 | 022-0031-0 | Hose | 1 | |
| 23A | 020-9911-3 | Hose Band, 90mm | 2 | |
| 23B | 020-9911-4 | Hose Band, 100mm | 2 | |
| 24C | 022-0740-3 | Tube End, 90mm X Flange With Pipe and Shut off Mount. | 1 | |
| 24D | 022-0740-2 | Tube End, 100mm X Flange With Pipe and Shut off Mount. | 1 | |
| 25 | 020-0114-0 | Chain, 1/2" Pitch | FT. | 9.7 |
| 26 | 022-0111-0 | Link, Connector 1/2" Pitch | 1 | |
| 27 | 022-0110-0 | Link, Offset 1/2" Pitch | 2 |
Page 9
| Spool Assembly | ||||
| No. | Part Number | Description | Qty. | |
| 28A | 584-0175-0 | Tube, PE 90mm X 3.0" ID 1000 Ft. | 1 | |
| 28B | 584-0175-2 | Tube, PE 90mm X 3.0" ID 1100 Ft. (Optional) | 1 | |
| 28C | 584-0174-0 | Tube, PE 100mm X 3.3" ID 800 Ft. (Standard) | 1 | |
| 28D | 584-0175-4 | Tube, PE 90mm X 3.0" ID 1050 Ft. (Standard) | 1 | |
| 29 | 022-0458-0 | Spool | 1 | |
| 30 | 022-0036-0 | Washer , Wear | 1 | |
| 31 | 020-9920-2 | Gasket | 1 | |
| 32 | 022-1037-0 | O-Ring 3.35 x .210 | 1 | |
| 35 | 022-0754-2 | Spacer D2 | 1 | |
| 36 | 022-0741-1 | Stop | 1 |
Page 11
| Levelwind Assembly | ||||
| No. | Part Number | Description | Qty. | |
| 1A | 021-9947-7 | Frame, Levelwind (Base D2) | 1 | |
| 1B | 022-0105-0 | Levelwind Assembly Complete Less #19-20 | 1 | |
| 3 | 020-0047-5 | Sprocket, 13 Tooth Idler | 1 | |
| 4 | 526-6254-0 | Snap Ring | 1 | |
| 5 | 020-0049-6 | Guide Link | 1 | |
| 6 | 020-0077-6 | Retaining Clip | 1 | |
| 7 | 020-0014-1 | Fork Support | 1 | |
| 9 | 553-0628-0 | Spacer, 1 1/2 X 1 X 18 Ga. | 1 | |
| 10 | 020-0047-9 | Sprocket, 13 Tooth Driver | 1 | |
| 11 | 589-0214-0 | Spring Pin, 7mm X 45mm | 1 | |
| 12 | 020-0015-3 | Hub, Sprocket | 1 | |
| 13 | 020-0015-2 | Set Screw | 1 | |
| 14 | 020-0108-5 | Angle Drive Gearbox | 1 | |
| 15 | 022-0124-0 | Sprocket, .5 X 29 Teeth (Model 30) | 1 | |
| 16 | 022-0125-0 | Sprocket, .5 X 25 Teeth (Model 33) | 1 | |
| 17 | 022-0386-1 | Sprocket, .5 X 32 Teeth (Model 27) | 1 | |
| 19 | 020-0460-7 | Fork (30, 90mm)(27, 82mm) | 1 | |
| 20 | 022-0385-0 | Fork (33, 100mm) | 1 | |
| 23 | 020-0114-1 | Chain, 5/8 (Base D2) 150 Rollers | FT. | 6.25 |
| 23A | 302-1644-1 | Link, 5/8 | 1 | |
| 24 | 020-0108-4 | Bushing | 4 | |
| 26 | 022-0122-0 | Shield, Levelwind Chain | 1 | |
| 27 | 022-0123-2 | Shield, Levelwind Chain | 1 | |
Page 13
| Shut Off | ||||
| No. | Part Number | Description | Qty. | |
| 1 | 022-0528-0 | Compensator Bar | 1 | |
| 2 | 020-0016-4 | Retainer | 1 | |
| 5 | 020-0016-6 | Spring, Compensator Torsion | 1 | |
| 6 | 022-0163-0 | Cap Plugs | 4 |
Page 15
| Boom Lift | ||||
| No. | Part Number | Description | Qty. | |
| 1 | 402-4906-0 | Pulley, 2 X 17/32 WRP | 1 | |
| 2 | 325-5191-0 | Bushing, .56 X .843 X .62 Long | 1 | |
| 3 | 400-4855-1 | Winch, Fulton K 1550 | 1 | |
| 4 | 500-0031-0 | Boom | 1 | |
| 5 | 500-0028-0 | Clamp, Plate | 1 | |
| 6 | 594-0524-1 | Brace, Boom | 1 | |
| 7 | 594-0522-0 | Boom Lift | 1 | |
| 8 | 594-0524-2 | Brace | 1 | |
| 9 | 750-4844-0 | Cable, 1/4 - 7 X 19 Galv. | FT. | 10 |
| 10 | 523-5565-0 | Hook Slip By Clevis 3/8" | 1 |
Page 17
| Shield Group | ||||
| No. | Part Number | Description | Qty. | |
| 1 | 022-0481-0 | Hood | 1 | |
| 2 | 022-0123-2 | Shield, Levelwind Chain | 1 | |
| 3 | 593-0039-0 | Shield Spool | 6 | |
| 4 | 022-0122-0 | Shield, Levelwind Chain | 1 | |
| 5 | 022-0388-0 | Shield, Belt | 1 | |
| 6 | 022-0389-0 | Hinge | 1 | |
Page 19
| Turbine Assembly 25/120 | ||||
| No. | Part Number | Description | Qty. | |
| 1 | 022-0198-0 | Nut, Self Locking Thin 14 X 1.5mm | 1 | |
| 2 | 022-0199-4 | Impeller 6.77 OD X .51 Vane Height | 1 | |
| 3 | 022-0543-0 | Spacer Mylar, .039" Thick | 2 | |
| 4 | 022-0300-0 | Spacer , .28" Thick X .64" ID X 1.0" OD | 1 | |
| 5 | 022-0544-0 | Spacer, Dia 25mm x 20mm x 5mm | 1 | |
| 6 | 022-0545-0 | Seal 20 X 6 | 1 | |
| 7 | 022-0546-0 | O-ring 2.30" id x .103" c/s | 2 | |
| 8 | 022-0546-1 | O-ring 2.362" id x .103" c/s | 1 | |
| 9 | 022-0548-0 | Turbine Housing T200 | 1 | |
| 11 | 022-0337-0 | Key 5mm X 5mm X 10mm | 1 | |
| 12 | 022-0550-0 | Impeller Shaft | 1 | |
| 13 | 022-0551-0 | Key 6 X 50 | 1 | |
| 14 | 022-0167-0 | Bearing, 6204 2RS | 1 | |
| 15 | 022-0552-1 | Spacer 1.8" long | 1 | |
| 16 | 022-0167-1 | Bearing, 5204 2RS | 1 | |
| 17 | 022-0324-0 | Retaining Ring i47 | 1 | |
| 18 | 022-0323-0 | Retaining Ring E20 | 1 | |
| 19 | 022-0592-0 | Pulley Three Step | 1 | |
| 20 | 022-0594-0 | Belt AX-67 | 1 | |
| 21 | 022-0414-0 | Hand Grip | 1 | |
| 22 | 022-0557-0 | Plate By-Pass Lever | 1 | |
| 23 | 022-0558-0 | Lever | 1 | |
| 24 | 022-0559-0 | O-ring 120 15,54 X 2.62 | 2 | |
| 25 | 022-0319-0 | Key, 6mm x 6mm x 10mm | 2 | |
| 26 | 022-0305-0 | Screw, 6 X 16 | 2 | |
| 27 | 022-0648-0 | Arm, Comp | 1 | |
| 28 | 022-0562-0 | Disc, By-Pass | 1 | |
| 29 | 022-0563-2 | By-Pass Shaft | 1 | |
| 32 | 022-0564-0 | By-Pass Lever | 1 | |
| 33 | 022-0565-0 | Washer 10 X 30 | 2 | |
| 35 | Nut, M10 | 1 | ||
| 36 | 022-0318-0 | Spring | 1 | |
| 37 | 022-0317-0 | Spring Support | 1 | |
| 38 | 022-0312-0 | U-bolt Dia 8 | 1 | |
| 39 | Nut, 8mm | 1 | ||
| 40 | 022-0574-0 | By-Pass Rod | 1 | |
| 41 | 022-0316-2 | Tie Rod | 1 | |
| 42 | 022-0566-0 | Regulator Flap With Pin | 1 | |
| 43 | 022-0331-0 | O-ring 1/2"ODX3/8"IDX1/16"CS | 2 | |
| 44 | 022-0650-0 | Loop, Comp. | 1 | |
| 45 | 022-0649-0 | Link, Comp. | 1 | |
| 46 | 022-0569-0 | By-Pass Rod | 1 | |
| 47 | Nut, 8mm Flat | 2 | ||
| 48 | 022-0341-0 | Rod End | 1 |
Page 21
| Turbine Assembly 25/120 | ||||
| No. | Part Number | Description | Qty. | |
| 49 | 022-0302-1 | Turbine Body 25/120 | 1 | |
| 50 | 022-0484-0 | O-ring 4.109" ID X .139" CS | 2 | |
| 51 | 022-0571-0 | Support | 1 | |
| 52 | 599-0146-0 | Gauge Protector | 1 | |
| 54 | 586-0675-0 | Gauge 0-300 | 1 | |
| 55 | 022-0457-2 | Elbow, Upper 25/120 Turbine | 1 | |
| 56 | 022-0389-0 | Hinge | 1 | |
| 57 | 022-0388-0 | Shield, Belt | 1 | |
| 58 | 022-0572-0 | O-ring i 286 X 3.53 | 1 | |
| 60 | 022-0573-0 | Stop Plate | 1 | |
| 61 | 022-0391-0 | Knob | 1 | |
| 64 | 022-0483-0 | Lower Feeding Elbow | 1 | |
| 70 | 022-0834-0 | Cover, Turbine 25/120 | 1 | |
| 72 | 588-0023-3 | O-ring 4" | 1 | |
| 73 | 525-4915-2 | Ftg, TB 90 Deg. 1/4"MNPT x 5/16" Tube | 1 | |
| 74 | 252-4939-2 | Tube, Synflex 5/16" | FT. | 2 |
| 75 | 599-0148-0 | Gauge Mount | 1 | |
| 76 | 525-4915-4 | Ftg, TB Straight 1/4"MNPT x 5/16" Tube | 1 | |
| 77 | 022-0695-0 | Complete Turbine | 1 |
Page 23
| Gearbox R93 | ||||
| No. | Part Number | Description | Qty. | |
| 1 | 022-0816-0 | Gearbox M1 93-1 ( Complete ) | 1 | |
| 2 | 022-0706-0 | Gearbox Housing 93-1 | 1 | |
| 3 | 022-0197-1 | Gearbox Cover | 1 | |
| 4 | 022-0641-0 | Breather | 1 | |
| 5 | 022-0164-1 | SHAFT, GEARBOX INPUT - 93-1 BOX Shaft | 1 | |
| 6 | 022-0165-0 | Oil Retainer 20 x 17 x 7 | 1 | |
| 7 | 022-0166-0 | Snap Ring i47 | 1 | |
| 8 | 022-0167-0 | Bearing, 6204 2RS | 1 | |
| 9 | 022-0168-0 | Snap Ring E20 | 1 | |
| 10 | 022-0169-0 | Bearing, 6201 | 3 | |
| 11 | 022-0170-0 | Snap Ring i32 | 3 | |
| 12 | 022-0171-0 | Plug, Dia. 32 | 2 | |
| 13 | 022-0174-0 | Snap Ring E12 | 3 | |
| 14 | 022-0172-0 | Oil Retainer 12 x 32 | 1 | |
| 15 | 022-0173-0 | Shaft | 1 | |
| 16 | 022-0175-0 | Shim Dia. 12. x 0.5 | 2 | |
| 17 | 022-0176-0 | Key 4mm x 10mm | 1 | |
| 18 | 022-0710-0 | Double, Pinion Z15 M1.5/Z150 M1 | 1 | |
| 19 | 022-0180-0 | Plug, Dia. 62 | 1 | |
| 20 | 022-0181-0 | Snap Ring i62 | 2 | |
| 21 | 022-0182-0 | Bearing 6206 ( no seals ) | 2 | |
| 22 | 022-0183-0 | Shim sp:3 | 1 | |
| 23 | 022-0712-0 | Gear, Z111 M1,5 | 1 | |
| 24 | 022-0711-0 | Spacer, sp:19.5 | 1 | |
| 25 | 022-0187-0 | Snap Ring E30 | 1 | |
| 26 | 022-0709-0 | Key, 8x20 | 1 | |
| 27 | 022-0179-0 | Shaft, Output | 1 | |
| 022-1026-0 | Shaft, Output Asm. (w/pins, etc.) | |||
| 28 | 022-0195-0 | Shaft, Splined | 1 | |
| 29 | 022-0193-0 | Pin, Bearing 1,9 x 17,5 | 62 | |
| 30 | 022-0190-0 | Spacer, i18x2.8 | 1 | |
| 31 | 022-0189-0 | Snap Ring E18 | 1 | |
| 32 | 022-0191-0 | Key, Safety With Pin | 1 | |
| 33 | 022-0194-0 | Spacer, i22x2.8 | 1 | |
| 34 | 022-0180-0 | Oil Seal 35mmx62mmx7mm | 1 | |
Page 25
| Drive Train Group | ||||
| No. | Part Number | Description | Qty. | |
| 1 | 022-0342-0 | Snap Ring E25 | 1 | |
| 2 | 022-0343-0 | Snap Ring | 2 | |
| 3 | 022-0344-0 | Bearing, 6005 2RS | 2 | |
| 4 | 022-0345-0 | Spacer Dia. 26 | 2 | |
| 6 | 022-0346-1 | Sprocket 5/8" Z75 | 1 | |
| 7 | 022-0347-0 | Spring | 1 | |
| 8 | 022-0348-0 | Pin | 1 | |
| 9 | 022-0349-0 | Pin | 1 | |
| 10 | 022-0459-0 | Shaft,Dia40mm(D2)7.3"Long On40mm End | 1 | |
| 11 | 022-0837-0 | Spacer | 1 | |
| 12 | 022-0460-0 | Key, 8mm X 12mm X 40mm | 1 | |
| 13 | 022-0462-0 | Bearing, 6208 2RS | 2 | |
| 14 | 022-0463-0 | Spacer | 1 | |
| 15 | 022-0532-0 | Pinion DIA. 40xZ7 | 1 | |
| 16 | 022-0359-0 | Washer Special | 1 | |
| 17 | 550-7011-0 | Screw 10mm x 25mm Allen Flat Head | 1 | |
| 18 | 022-0534-0 | Snap Ring E35 | 2 | |
| 19 | 022-0535-0 | Spacer Dia. 35 X 1 | 2 | |
| 20 | 022-0362-0 | Sprocket 5/8" Z12 | 1 | |
| 21 | 020-0114-1 | Chain 5/8" 93 Rollers | FT. | 4.8 |
| 24 | 022-0593-0 | Pulley, 100mm x 125mm x 147mm ( Pulley OD's ) | 1 | |
| 25 | 022-0370-0 | Key 6 X 50 | 1 | |
| 27 | 595-0482-1 | Tach Pulley 1.64 | 1 | |
| 28 | 022-0367-0 | Meter Counter Support | 1 | |
| 29 | 022-0366-1 | Belt, Dia. 3.5mm X 590mm | 1 | |
| 30 | 022-0120-0 | Tach | 1 | |
| 31 | 022-0651-0 | Lever, For Belt | 1 | |
| 32 | 022-0372-0 | End Support | 1 | |
| 33 | 594-0441-1 | Pulley, Tach .966 | 1 | |
| 34 | 022-0838-0 | Turbine Mechanism Support | 1 | |
| 35 | 022-0371-0 | Pin, Non Return Key | 1 | |
| 36 | 022-0356-0 | Antireverse Key | 1 | |
| 39 | 022-0344-0 | Bearing 6005 2RS | 2 | |
| 40 | 022-0653-0 | Shaft, Belt Idler | 1 | |
| 41 | 022-0654-0 | Pulley Idler 3 Groove | 1 | |
| 42 | 022-0703-0 | Spacer, 1mm x 25mm x 35mm | 1 | |
| 43 | 022-0318-0 | Spring | 1 | |
| 46 | 022-0816-0 | Gearbox M1 93-1 ( Complete ) ( Not Shown ) | 1 | |
| 47 | 022-0438-0 | Cover, PTO | 1 |
Page 27
| Sprinkler Cart Assembly | ||||
| No. | Part Number | Description | Qty. | |
| 1 | 500-0371-0 | Lift Bail | 1 | |
| 2A | 599-0417-0 | Body, Guncart Without Shut Off Bar | 1 | |
| 3 | 850-4059-0 | Chain 3/16" Proof Coil ( Per Foot ) ( 10 Links ) | FT | |
| 4 | 595-0003-0 | Yoke, Front Guncart | 1 | |
| 5 | 060-1019-9 | Axle, Front | 1 | |
| 6 | 500-0021-0 | Leg, Inner 30 Cart | 1 | |
| 7 | 594-0603-0 | Strap | 3 | |
| 8 | 500-0020-0 | Leg, Outer 30 | 1 | |
| 9 | 060-0245-0 | Sleeve | 1 | |
| 10A | 588-0495-0 | Hub W/Race, Wilton 280301 | 1 | |
| 10B | 595-0382-0 | Hub & Axle Assy. Complete ( Not Shown ) | 1 | |
| 11 | 596-0137-0 | Spindle | 2 | |
| 12 | 597-0312-0 | Cap, Guncart | 1 | |
| 13 | 588-0023-3 | O-ring 4" | 1 | |
| 14A | 593-0265-0 | Tire, 16 X 6.5 X 8 4 Ply | 1 | |
| 14B | 593-0265-1 | Tube, Inner 16 X 3.5 X 8 | 1 | |
| 15 | 850-4060-0 | Chain 3/8 Proof Coil | FT. | 3 |
| 16 | 523-5394-1 | Clevis, Double | 2 | |
| 17 | 523-5421-0 | Hitch, Chain | 1 | |
| 18 | 593-0264-0 | Wheel, 8 X 5.75 4 Bolt 4 BCD | 1 | |
| 18B | 595-0606-0 | Wheel & Tire Assembly | 1 | |
| 19 | 588-0356-6 | Race, L44610 | 2 | |
| 20 | 586-0229-4 | Wheel & Tire, 4:80 x 12 x 4 Bolt Galv. | 2 | |
| 21 | 588-0356-8 | Bearing, Timken L-44649 | 4 | |
| 22 | 588-0356-6 | Race, L44610 | 4 | |
| 23 | 588-0356-0 | Bolt, Hub Wilton 913535 | 8 | |
| 24 | 588-0356-4 | Hub | 2 | |
| 25 | 588-0356-5 | Seal, Grease Wilton 906282 | 2 | |
| 26 | 588-0356-7 | Washer, Spindle Wilton 913608 | 2 | |
| 27 | 588-0356-1 | Cap, Hub Wilton 909981 | 8 | |
| 29 | 588-0356-2 | Nut, Wilson 912953 | 2 | |
| 32 | 588-0356-5 | SealCR 12437 | 2 | |
| 33 | 551-1602-0 | Nut, 1" NF Slotted | 1 | |
| 34 | 588-0357-7 | Washer, Wilton 913535 | 2 | |
| 35 | 588-0356-3 | Bearing L 44643 | 2 | |
| 36 | 588-0356-0 | Bolt, Lug | 4 |
Page 29
| Decal Group | ||||
| No. | Part Number | Description | Qty. | |
| 1 | 594-0565-1 | Decal, Warning& Caution | 1 | |
| 2 | 594-0565-0 | Decal, Instructions | 1 | |
| 3 | 595-0275-1 | Decal, PTO Rewind | 1 | |
| 4 | 595-0275-2 | Decal, Anti-Return Pawl | 1 | |
| 5 | 585-0299-2 | Decal, 6" Round Logo | 6 | |
| 6 | 595-0501-0 | Decal, Important (Engine) | 1 | |
| 7 | 590-0113-0 | Decal, Gasoline | 1 | |
| 8 | 585-0404-2 | Decal, Ag-Rain 3" Letters | 3 | |
| 9 | 596-0017-0 | Decal, Supply Hose | 1 | |
| 10 | 590-0013-0 | Decal, Keep Levelwind Slide Bar Grease | 1 | |
| 11 | 599-0369-0 | Decal, Performance Guide 30A | 1 | |
| 12 | 599-0370-0 | Decal, Performance Guide 33A | 1 | |
| 16 | 596-0428-0 | Decal, Lub. (Not Shown) | 1 | |
| 17 | 596-0309-0 | Decal, Brake Adj. (Not Shown) | 1 | |
| 19 | 596-0426-0 | Decal, Change Oil | 1 | |
| 22 | 597-0055-0 | Decal, Warning Read Operator Manual | 1 |
Page 31
| Mechanical Engine Drive Assembly | ||||
| No. | Part Number | Description | Qty. | |
| 1 | 599-0194-0 | Cradle Plate | 1 | |
| 2 | 599-0041-0 | Switch Arm 30A | 1 | |
| 3 | 586-0075-0 | Switch, Chery E/72-40H | 1 | |
| 4 | 599-0039-0 | Throttle Brkt. 30A | 1 | |
| 5 | 599-0132-0 | Throttle Control Cable | 1 | |
| 6 | 599-0043-0 | Switch Ramp | 1 | |
| 7 | 599-0028-0 | Throttle Link | 1 | |
| 8 | 599-0026-1 | Backing Plate | 1 | |
| 9 | 599-0253-0 | Jackshaft Mount | 1 | |
| 10 | 599-0066-0 | Throttle Mount | 1 | |
| 11 | 302-4915-0 | Ball KNOB | 1 | |
| 12 | 599-0042-0 | Slide, Switch | 1 | |
| 13 | 512-4847-0 | Bushing, Stl .56 x .40 x .32L | 1 | |
| 14 | 599-0027-0 | Swivel | 1 | |
| 15 | 526-5670-0 | Knob, 3/8 x 1.0 Stud | 1 | |
| 16 | 599-0338-0 | Bearing, 2 Hole Flange ( Cast Iron Housing ) | 2 | |
| 17 | 599-0277-0 | Jack Shaft | 1 | |
| 18 | 599-0084-0 | Pulley, 3 Step 2"-3"-4" 3/4" Bore | 1 | |
| 19 | 599-0341-0 | Pulley, 3" x 3/4" Bore | 2 | |
| 20 | 599-0255-2 | Engine Mount 30A | 1 | |
| 21A | 599-0219-1 | Fuel Tank 4 HP Robin | 1 | |
| 21B | 599-0443-0 | Fuel Tank 8 HP Honda | 1 | |
| 22A | 599-0221-0 | Cap, Robin | 1 | |
| 22B | 599-0221-1 | Cap, Honda | 1 | |
| 23 | 599-0432-0 | Plate | 1 | |
| 24 | 022-0593-0 | Pulley, 100mm x 125mm x 147mm | 1 | |
| 25 | 450-4858-2 | Spring, .5 OD x 2 x .47 | 1 | |
| 26 | 599-0422-0 | Spring, .045"w x .38 OD x 2.5" Long | 1 | |
| 27 | 599-0324-0 | Wire Harness A Series | 1 | |
| 28 | 599-0279-0 | Switch, Robin Shut Off | 1 | |
| 29 | 599-0344-0 | Switch Holder | 1 | |
| 30A | 599-0293-0 | Pulley 2" 3/4" Bore | 1 | |
| 31A | 598-0141-1 | Engine, Robin 4HP | 1 | |
| 31B | 584-0701-7 | Engine, Honda 4HP | 1 | |
| 32 | 599-0265-0 | Spring Holder | 1 | |
| 33 | 022-0322-0 | Belt, AX36 | 1 | |
| 34a | 599-0075-2 | Entry Fitting 33A | 1 | |
| 34b | 599-0075-1 | Entry Fitting 30A ( Not as shown has 3 bolt flange) | 1 | |
| 35 | 599-0323-0 | Shield | 1 | |
| 36 | 599-0429-0 | Strap | 1 | |
| 37 | 599-0035-0 | Throttle Pivot Arm | 1 | |
| 38 | 599-0343-0 | Belt, AX 42 | 1 | |
| 39 | 599-0034-0 | Link Shut Off | 1 | |
| 40 | 599-0424-0 | Strap | 1 | |
| 41 | 599-0430-0 | Switch Contact | 1 | |
| 42 | 599-0324-0 | Wire Harness | 1 | |
| 43 | 599-0325-0 | Connector | 1 | |
| 44 | 586-0675-0 | Gauge, 0-300 | 1 | |
| 45 | 586-0690-1 | Gauge Protector Top | 1 | |
| 46 | 587-0046-0 | Diaphragm | 1 | |
| 47 | 599-0485-0 | Bracket Throttle Cable | 1 |
Page 32
| Numerical Parts Listing | ||||
| Page | ||||
| No. | Part Number | Description | Qty. | |
| 18 | Nut, 8mm | 1 | ||
| 18 | Nut, 8mm Flat | 2 | ||
| 18 | Nut, M10 | 1 | ||
| 10 | 020-0014-1 | Fork Support | 1 | |
| 10 | 020-0015-2 | Set Screw | 1 | |
| 10 | 020-0015-3 | Hub, Sprocket | 1 | |
| 14 | 020-0016-4 | Retainer | 1 | |
| 14 | 020-0016-6 | Spring, Compensator Torsion | 1 | |
| 10 | 020-0047-5 | Sprocket, 13 Tooth Idler | 1 | |
| 10 | 020-0047-9 | Sprocket, 13 Tooth Driver | 1 | |
| 10 | 020-0049-6 | Guide Link | 1 | |
| 10 | 020-0077-6 | Retaining Clip | 1 | |
| 10 | 020-0108-4 | Bushing | 4 | |
| 10 | 020-0108-5 | Angle Drive Gearbox | 1 | |
| 6 | 020-0114-0 | Chain, 1/2" Pitch | FT. | 9.7 |
| 10 | 020-0114-1 | Chain, 5/8 (Base D2) 150 Rollers | FT. | 6.25 |
| 24 | 020-0114-1 | Chain 5/8" 93 Rollers | FT. | 4.8 |
| 10 | 020-0460-7 | Fork (30, 90mm)(27, 82mm) | 1 | |
| 4 | 020-1012-7 | Pawl | 2 | |
| 4 | 020-1012-8 | Spring Right | 1 | |
| 4 | 020-1012-9 | Pin | 2 | |
| 4 | 020-1013-5 | Spring Left | 1 | |
| 4 | 020-1041-0 | Roller, Horizontal (D2) & (A1) | 1 | |
| 4 | 020-9904-8 | Handle | 2 | |
| 4 | 020-9904-9 | Washer, Plastic | 2 | |
| 4 | 020-9905-6 | Bushing | 2 | |
| 4 | 020-9905-8 | Retainer Nut | 2 | |
| 4 | 020-9905-9 | Spring, Rubber | 2 | |
| 6 | 020-9911-3 | Hose Band, 90mm | 2 | |
| 6 | 020-9911-4 | Hose Band, 100mm | 2 | |
| 8 | 020-9920-2 | Gasket | 1 | |
| 4 | 020-9957-8 | Crank, 30 | 2 | |
| 6 | 020-9958-1 | Bearing, Spool | 1 | |
| 2 | 020-9963-6 | Bearing, Turntable | 1 | |
| 10 | 021-9947-7 | Frame, Levelwind (Base D2) | 1 | |
| 4 | 022-0027-0 | Stabilizer Foot, Left | 1 | |
| 4 | 022-0028-0 | Stabilizer Foot, Right | 1 | |
| 4 | 022-0029-0 | Stabilizer Leg, Right | 1 | |
| 4 | 022-0030-0 | Stabilizer Leg, Left | 1 | |
| 6 | 022-0031-0 | Hose | 1 |
Page 33
| Numerical Parts Listing | ||||
| Page | ||||
| No. | Part Number | Description | Qty. | |
| 6 | 022-0032-0 | Bearing | 1 | |
| 6 | 022-0034-0 | Elbow, PE Tube 90mm | 1 | |
| 8 | 022-0036-0 | Washer , Wear | 1 | |
| 6 | 022-0037-0 | Ring, Snap | 3 | |
| 6 | 022-0038-0 | Spacer | 2 | |
| 6 | 022-0039-0 | O-ring, 124mm x 3.53mm | 1 | |
| 6 | 022-0040-0 | Washer, Thrust | 1 | |
| 10 | 022-0105-0 | Levelwind Assembly Complete Less #19-20 | 1 | |
| 6 | 022-0110-0 | Link, Offset 1/2" Pitch | 2 | |
| 6 | 022-0111-0 | Link, Connector 1/2" Pitch | 1 | |
| 24 | 022-0120-0 | Tach | 1 | |
| 10 | 022-0122-0 | Shield, Levelwind Chain | 1 | |
| 16 | 022-0122-0 | Shield, Levelwind Chain | 1 | |
| 10 | 022-0123-2 | Shield, Levelwind Chain | 1 | |
| 16 | 022-0123-2 | Shield, Levelwind Chain | 1 | |
| 10 | 022-0124-0 | Sprocket, .5 X 29 Teeth (Model 30) | 1 | |
| 10 | 022-0125-0 | Sprocket, .5 X 25 Teeth (Model 33) | 1 | |
| 6 | 022-0127-0 | Elbow, PE Tube 100mm | 1 | |
| 4 | 022-0156-0 | Hitrel Washer | 2 | |
| 4 | 022-0157-1 | Brake Plate, Threaded | 1 | |
| 4 | 022-0158-1 | Brake Plate | 1 | |
| 4 | 022-0159-0 | Brake Control Screw | 1 | |
| 4 | 022-0160-1 | Pin, Brake | 2 | |
| 14 | 022-0163-0 | Cap Plugs | 4 | |
| 22 | 022-0165-0 | Oil Retainer 20 x 17 x 7 | 1 | |
| 22 | 022-0166-0 | Snap Ring i47 | 1 | |
| 18 | 022-0167-0 | Bearing, 6204 2RS | 1 | |
| 22 | 022-0167-0 | Bearing, 6204 2RS | 1 | |
| 18 | 022-0167-1 | Bearing, 5204 2RS | 1 | |
| 22 | 022-0168-0 | Snap Ring E20 | 1 | |
| 22 | 022-0169-0 | Bearing, 6201 | 3 | |
| 22 | 022-0170-0 | Snap Ring i32 | 3 | |
| 22 | 022-0171-0 | Plug, Dia. 32 | 2 | |
| 22 | 022-0172-0 | Oil Retainer 12 x 32 | 1 | |
| 22 | 022-0173-0 | Shaft | 1 | |
| 22 | 022-0174-0 | Snap Ring E12 | 3 | |
| 22 | 022-0175-0 | Shim Dia. 12. x 0.5 | 2 | |
| 22 | 022-0176-0 | Key 4mm x 10mm | 1 | |
| 22 | 022-0179-0 | Shaft, Output | 1 | |
| 22 | 022-0180-0 | Plug, Dia. 62 | 1 | |
| 22 | 022-0180-0 | Oil Seal 35mmx62mmx7mm | 1 | |
| 22 | 022-0181-0 | Snap Ring i62 | 2 |
Page 34
| Numerical Parts Listing | ||||
| Page | ||||
| No. | Part Number | Description | Qty. | |
| 22 | 022-0182-0 | Bearing, 6206 | 2 | |
| 22 | 022-0183-0 | Shim sp:3 | 1 | |
| 22 | 022-0187-0 | Snap Ring E30 | 1 | |
| 22 | 022-0189-0 | Snap Ring E18 | 1 | |
| 22 | 022-0190-0 | Spacer, i18x2.8 | 1 | |
| 22 | 022-0191-0 | Key, Safety With Pin | 1 | |
| 22 | 022-0193-0 | Pin, Bearing 1,9 x 17,5 | 62 | |
| 22 | 022-0194-0 | Spacer, i22x2.8 | 1 | |
| 22 | 022-0195-0 | Shaft, Splined | 1 | |
| 22 | 022-0197-1 | Gearbox Cover | 1 | |
| 18 | 022-0198-0 | Nut, Self Locking Thin 14 X 1.5mm | 1 | |
| 18 | 022-0199-4 | Impeller 6.77 OD X .51 Vane Height | 1 | |
| 18 | 022-0300-0 | Spacer , .28" Thick X .64" ID X 1.0" OD | 1 | |
| 20 | 022-0302-1 | Turbine Body 25/120 | 1 | |
| 18 | 022-0305-0 | Screw, 6 X 16 | 2 | |
| 18 | 022-0312-0 | U-bolt Dia 8 | 1 | |
| 18 | 022-0316-2 | Tie Rod | 1 | |
| 18 | 022-0317-0 | Spring Support | 1 | |
| 18 | 022-0318-0 | Spring | 1 | |
| 24 | 022-0318-0 | Spring | 1 | |
| 18 | 022-0319-0 | Key, 6mm x 6mm x 10mm | 2 | |
| 30 | 022-0322-0 | Belt, AX36 | 1 | |
| 18 | 022-0323-0 | Retaining Ring E20 | 1 | |
| 18 | 022-0324-0 | Retaining Ring i47 | 1 | |
| 18 | 022-0331-0 | O-ring 1/2"ODX3/8"IDX1/16"CS | 2 | |
| 18 | 022-0337-0 | Key 5mm X 5mm X 10mm | 1 | |
| 18 | 022-0341-0 | Rod End | 1 | |
| 24 | 022-0342-0 | Snap Ring E25 | 1 | |
| 24 | 022-0343-0 | Snap Ring | 2 | |
| 24 | 022-0344-0 | Bearing 6005 2RS | 2 | |
| 24 | 022-0344-0 | Bearing, 6005 2RS | 2 | |
| 24 | 022-0345-0 | Spacer Dia. 26 | 2 | |
| 24 | 022-0346-1 | Sprocket 5/8" Z75 | 1 | |
| 24 | 022-0347-0 | Spring | 1 | |
| 24 | 022-0348-0 | Pin | 1 | |
| 24 | 022-0349-0 | Pin | 1 | |
| 24 | 022-0356-0 | Antireverse Key | 1 | |
| 24 | 022-0359-0 | Washer Special | 1 | |
| 24 | 022-0362-0 | Sprocket 5/8" Z12 | 1 | |
| 24 | 022-0366-1 | Belt, Dia. 3.5mm X 590mm | 1 | |
| 24 | 022-0367-0 | Meter Counter Support | 1 | |
| 24 | 022-0370-0 | Key 6 X 50 | 1 | |
| 24 | 022-0371-0 | Pin, Non Return Key | 1 | |
| 24 | 022-0372-0 | End Support | 1 | |
| 10 | 022-0385-0 | Fork (33, 100mm) | 1 | |
| 10 | 022-0386-1 | Sprocket, .5 X 32 Teeth (Model 27) | 1 |
Page 35
| Numerical Parts Listing | ||||
| Page | ||||
| No. | Part Number | Description | Qty. | |
| 16 | 022-0388-0 | Shield, Belt | 1 | |
| 20 | 022-0388-0 | Shield, Belt | 1 | |
| 16 | 022-0389-0 | Hinge | 1 | |
| 20 | 022-0389-0 | Hinge | 1 | |
| 20 | 022-0391-0 | Knob | 1 | |
| 18 | 022-0414-0 | Hand Grip | 1 | |
| 24 | 022-0438-0 | Cover, PTO | 1 | |
| 4 | 022-0454-0 | Slide, (Brake Pad) | 2 | |
| 6 | 022-0457-2 | Elbow, Upper | 1 | |
| 20 | 022-0457-2 | Elbow, Upper 25/120 Turbine | 1 | |
| 8 | 022-0458-0 | Spool | 1 | |
| 24 | 022-0459-0 | Shaft | 1 | |
| 24 | 022-0460-0 | Key, 8mm X 12mm X 40mm | 1 | |
| 24 | 022-0462-0 | Bearing, 6208 2RS | 2 | |
| 24 | 022-0463-0 | Spacer | 1 | |
| 4 | 022-0479-0 | PTO Rewind Crank ( Not Shown ) | 1 | |
| 16 | 022-0481-0 | Hood | 1 | |
| 6 | 022-0483-0 | Lower Feeder Pipe 3-1/2" | 1 | |
| 20 | 022-0483-0 | Lower Feeding Elbow | 1 | |
| 6 | 022-0484-0 | O-Ring 318mm OD x 3.53mm | 2 | |
| 20 | 022-0484-0 | O-ring 4.109" ID X .139" CS | 2 | |
| 4 | 022-0527-0 | Brkt. Brake Mt. | 1 | |
| 14 | 022-0528-0 | Compensator Bar | 1 | |
| 24 | 022-0532-0 | Pinion DIA. 40xZ7 | 1 | |
| 24 | 022-0534-0 | Snap Ring E35 | 2 | |
| 24 | 022-0535-0 | Spacer Dia. 35 X 1 | 2 | |
| 18 | 022-0543-0 | Spacer Mylar, .039" Thick | 2 | |
| 18 | 022-0544-0 | Spacer, Dia 25mm x 20mm x 5mm | 1 | |
| 18 | 022-0545-0 | Seal 20 X 6 | 1 | |
| 18 | 022-0546-0 | O-ring 2.30" id x .103" c/s | 2 | |
| 18 | 022-0546-1 | O-ring 2.362" id x .103" c/s | 1 | |
| 18 | 022-0548-0 | Turbine Housing T200 | 1 | |
| 18 | 022-0550-0 | Impeller Shaft | 1 | |
| 18 | 022-0551-0 | Key 6 X 50 | 1 | |
| 18 | 022-0552-1 | Spacer 1.8" long | 1 | |
| 18 | 022-0557-0 | Plate By-Pass Lever | 1 | |
| 18 | 022-0558-0 | Lever | 1 | |
| 18 | 022-0559-0 | O-ring 120 15,54 X 2.62 | 2 | |
| 18 | 022-0562-0 | Disc, By-Pass | 1 | |
| 18 | 022-0563-2 | By-Pass Shaft | 1 | |
| 18 | 022-0564-0 | By-Pass Lever | 1 | |
| 18 | 022-0565-0 | Washer 10 X 30 | 2 | |
| 18 | 022-0566-0 | Regulator Flap With Pin | 1 | |
| 18 | 022-0569-0 | By-Pass Rod | 1 |
Page 36
| Numerical Parts Listing | ||||
| Page | ||||
| No. | Part Number | Description | Qty. | |
| 20 | 022-0571-0 | Support | 1 | |
| 20 | 022-0572-0 | O-ring i 286 X 3.53 | 1 | |
| 20 | 022-0573-0 | Stop Plate | 1 | |
| 18 | 022-0574-0 | By-Pass Rod | 1 | |
| 4 | 022-0576-0 | Pin, | 2 | |
| 18 | 022-0592-0 | Pulley Three Step | 1 | |
| 24 | 022-0593-0 | Pulley, 100mm x 125mm x 147mm ( Pulley OD's ) | 1 | |
| 30 | 022-0593-0 | Pulley, 100mm x 125mm x 147mm | 1 | |
| 18 | 022-0594-0 | Belt AX-67 | 1 | |
| 22 | 022-0641-0 | Breather | 1 | |
| 18 | 022-0648-0 | Arm, Comp | 1 | |
| 18 | 022-0649-0 | Link, Comp. | 1 | |
| 18 | 022-0650-0 | Loop, Comp. | 1 | |
| 24 | 022-0651-0 | Lever, For Belt | 1 | |
| 24 | 022-0653-0 | Shaft, Belt Idler | 1 | |
| 24 | 022-0654-0 | Pulley Idler 3 Groove | 1 | |
| 6 | 022-0682-0 | Clamp, Hose Atlantic 86mm to 95mm | 4 | |
| 20 | 022-0695-0 | Complete Turbine | 1 | |
| 24 | 022-0703-0 | Spacer, 1mm x 25mm x 35mm | 1 | |
| 22 | 022-0706-0 | Gearbox Housing 93-1 | 1 | |
| 22 | 022-0709-0 | Key, 8x20 | 1 | |
| 22 | 022-0710-0 | Double, Pinion Z15 M1.5/Z150 M1 | 1 | |
| 22 | 022-0711-0 | Spacer, sp:19.5 | 1 | |
| 22 | 022-0712-0 | Gear, Z111 M1,5 | 1 | |
| 6 | 022-0740-2 | Tube End, 100mm X Flange With Pipe and Shut off Mount. | 1 | |
| 6 | 022-0740-3 | Tube End, 90mm X Flange With Pipe and Shut off Mount. | 1 | |
| 8 | 022-0741-1 | Stop | 1 | |
| 6 | 022-0753-2 | Seal, Housing | 1 | |
| 8 | 022-0754-2 | Spacer D2 | 1 | |
| 22 | 022-0816-0 | Gearbox M1 93-1 ( Complete ) | 1 | |
| 24 | 022-0816-0 | Gearbox M1 93-1 ( Complete ) ( Not Shown ) | 1 | |
| 20 | 022-0834-0 | Cover, Turbine 25/120 | 1 | |
| 22 | 022-0836-0 | Shaft | 1 | |
| 24 | 022-0837-0 | Spacer | 1 | |
| 24 | 022-0838-0 | Turbine Mechanism Support | 1 | |
| 6 | 030-1924-0 | Clamp, Supra 104-112 (4" Hose) | 4 | |
| 26 | 060-0245-0 | Sleeve | 1 | |
| 26 | 060-1019-9 | Axle, Front | 1 | |
| 8 | 022-1037-0 | O-ring, Shaft Seal 3.35 x .210 | 1 | |
| 2 | 226-1598-2 | Hub Assembly (Hub, Bearing & Races) | 2 | |
| 20 | 252-4939-2 | Tube, Synflex 5/16" | FT. | 2 |
| 6 | 252-4962-0 | Hose, Irr. Supply 4" | FT. | 30 |
| 10 | 302-1644-1 | Link, 5/8 | 1 | |
| 30 | 302-4915-0 | Ball KNOB | 1 | |
| 12 | 325-5191-0 | Bushing, .56 X .843 X .62 Long | 1 |
Page 37
| Numerical Parts Listing | ||||
| Page | ||||
| No. | Part Number | Description | Qty. | |
| 12 | 400-4855-1 | Winch, Fulton K 1550 | 1 | |
| 6 | 400-4927-0 | Band, Ring 4" | 1 | |
| 12 | 402-4906-0 | Pulley, 2 X 17/32 WRP | 1 | |
| 30 | 450-4858-2 | Spring, .5 OD x 2 x .47 | 1 | |
| 26 | 500-0020-0 | Leg, Outer 30 | 1 | |
| 26 | 500-0021-0 | Leg, Inner 30 Cart | 1 | |
| 2 | 500-0023-1 | Jack Assembly | 1 | |
| 12 | 500-0028-0 | Clamp, Plate | 1 | |
| 12 | 500-0031-0 | Boom | 1 | |
| 2 | 500-0038-0 | Spindle | 2 | |
| 2 | 500-0046-0 | Chassis | 1 | |
| 2 | 500-0046-1 | Spindle s/n 352,227 | 1 | |
| 2 | 500-0081-0 | Spindle s/n 352,227 | 1 | |
| 26 | 500-0371-0 | Lift Bail | 1 | |
| 2 | 500-0566-0 | Spindle | 2 | |
| 2 | 510-0940-0 | Race, Outer LM67010 | 2 | |
| 2 | 510-0940-1 | Race, Inner LM48510 | 2 | |
| 30 | 512-4847-0 | Bushing, Stl .56 x .40 x .32L | 1 | |
| 2 | 515-0939-0 | Bearing, Outer LM67048 | 2 | |
| 26 | 523-5394-1 | Clevis, Double | 2 | |
| 26 | 523-5421-0 | Hitch, Chain | 1 | |
| 12 | 523-5565-0 | Hook Slip By Clevis 3/8" | 1 | |
| 2 | 523-5866-0 | Pin, 3/4 x 6 1/2 Hitch | 1 | |
| 20 | 525-4915-2 | Ftg, TB 90 Deg. 1/4"MNPT x 5/16" Tube | 1 | |
| 20 | 525-4915-4 | Ftg, TB Straight 1/4"MNPT x 5/16" Tube | 1 | |
| 2 | 526-5138-1 | Wheel, 6 Bolt 15" x 10KB | 2 | |
| 2 | 526-5531-0 | Tire, 11L x 15 12 Ply | 2 | |
| 30 | 526-5670-0 | Knob, 3/8 x 1.0 Stud | 1 | |
| 10 | 526-6254-0 | Snap Ring | 1 | |
| 4 | 550-7010-0 | Bolt, 8-1.25 X 20mm Brass ( Brake Pad) | 4 | |
| 24 | 550-7011-0 | Screw 10mm x 25mm Allen Flat Head | 1 | |
| 26 | 551-1602-0 | Nut, 1" NF Slotted | 1 | |
| 10 | 553-0628-0 | Spacer, 1 1/2 X 1 X 18 Ga. | 1 | |
| 4 | 553-2413-0 | Washer, 3/4 Flat USS | 4 | |
| 2 | 558-3281-1 | Pin, 3/4 x 4 1/8 Hitch | 2 | |
| 2 | 561-0204-0 | Hair Pin | 2 | |
| 8 | 584-0174-0 | Tube, PE 100mm X 3.3" ID 800 Ft. (Standard) | 1 | |
| 8 | 584-0175-0 | Tube, PE 90mm X 3.0" ID 1000 Ft. | 1 | |
| 8 | 584-0175-2 | Tube, PE 90mm X 3.0" ID 1100 Ft. (Optional) | 1 | |
| 8 | 584-0175-4 | Tube, PE 90mm X 3.0" ID 1050 Ft. (Standard) | 1 | |
| 30 | 584-0701-7 | Engine, Honda 4HP | 1 | |
| 28 | 585-0299-2 | Decal, 6" Round Logo | 6 | |
| 28 | 585-0404-2 | Decal, Ag-Rain 3" Letters | 3 | |
| 30 | 586-0075-0 | Switch, Chery E/72-40H | 1 | |
| 26 | 586-0229-4 | Wheel & Tire, 4:80 x 12 x 4 Bolt Galv. | 2 | |
| 20 | 586-0675-0 | Gauge 0-300 | 1 | |
| 6 | 588-0023-1 | Lever Ring 4" 451 108mm | 1 | |
| 6 | 588-0023-3 | O-Ring 4" | 1 |
Page 38
| Numerical Parts Listing | ||||
| Page | ||||
| No. | Part Number | Description | Qty. | |
| 20 | 588-0023-3 | O-ring 4" | 1 | |
| 26 | 588-0023-3 | O-ring 4" | 1 | |
| 2 | 588-0250-2 | Hub Assembly ( Hub, Bearing & Races ) | 2 | |
| 2 | 588-0250-3 | Hub, With Races Only, Wilton 280511 | 2 | |
| 6 | 588-0256-1 | Hose End Outlet 4" | 1 | |
| 6 | 588-0266-0 | Hose End Inlet 4" | 1 | |
| 2 | 588-0355-0 | Cap, Wilton 909902 Hub | 2 | |
| 2 | 588-0355-3 | Seal, Grease CR15190 | 2 | |
| 2 | 588-0355-4 | Bearing, Inner LM48548 | 2 | |
| 2 | 588-0355-5 | Bolt, Lug 1/2-NF | 12 | |
| 26 | 588-0356-0 | Bolt, Hub Wilton 913535 | 8 | |
| 26 | 588-0356-0 | Bolt, Lug | 4 | |
| 26 | 588-0356-1 | Cap, Hub Wilton 909981 | 8 | |
| 26 | 588-0356-2 | Nut, Wilson 912953 | 2 | |
| 26 | 588-0356-3 | Bearing L 44643 | 2 | |
| 26 | 588-0356-4 | Hub | 2 | |
| 26 | 588-0356-5 | Seal, Grease Wilton 906282 | 2 | |
| 26 | 588-0356-5 | SealCR 12437 | 2 | |
| 26 | 588-0356-6 | Race, L44610 | 4 | |
| 26 | 588-0356-6 | Race, L44610 | 2 | |
| 26 | 588-0356-7 | Washer, Spindle Wilton 913608 | 2 | |
| 26 | 588-0356-8 | Bearing, Timken L-44649 | 4 | |
| 26 | 588-0357-7 | Washer, Wilton 913535 | 2 | |
| 26 | 588-0495-0 | Hub W/Race, Wilton 280301 | 1 | |
| 2 | 589-0199-0 | Hub, With Races Only, Wilton 280581 | 2 | |
| 2 | 589-0200-0 | Race, Inner LM25520 | 2 | |
| 2 | 589-0201-0 | Race, Outer LM25821 | 2 | |
| 2 | 589-0203-0 | Bearing, Inner LM25590 | 2 | |
| 2 | 589-0204-0 | Bearing, Outer LM25877 | 2 | |
| 2 | 589-0205-0 | Seal, Grease CR20148 | 2 | |
| 2 | 589-0206-0 | Hub Cap Wilton 90903 | 2 | |
| 2 | 589-0207-0 | Nut, 7/8-14"NF Slotted Wilton 912952 | 2 | |
| 2 | 589-0208-0 | Washer, Spindle Wilton 913607 | 2 | |
| 10 | 589-0214-0 | Spring Pin, 7mm X 45mm | 1 | |
| 28 | 590-0013-0 | Decal, Keep Levelwind Slide Bar Grease | 1 | |
| 28 | 590-0113-0 | Decal, Gasoline | 1 | |
| 6 | 593-0260-0 | Ringlock End, 4"x 6" | ||
| 16 | 593-0039-0 | Shield Spool | 6 | |
| 6 | 593-0245-1 | Ring Nut, Slip Joint | 1 | |
| 26 | 593-0264-0 | Wheel, 8 X 5.75 4 Bolt 4 BCD | 1 | |
| 26 | 593-0265-0 | Tire, 16 X 6.5 X 8 4 Ply | 1 | |
| 26 | 593-0265-1 | Tube, Inner 16 X 3.5 X 8 | 1 | |
| 24 | 594-0441-1 | Pulley, Tach .966 | 1 | |
| 12 | 594-0522-0 | Boom Lift | 1 | |
| 12 | 594-0524-1 | Brace, Boom | 1 | |
| 12 | 594-0524-2 | Brace | 1 | |
| 28 | 594-0565-0 | Decal, Instructions | 1 | |
| 28 | 594-0565-1 | Decal, Warning& Caution | 1 | |
| 26 | 594-0603-0 | Strap | 3 | |
| 26 | 595-0003-0 | Yoke, Front Guncart | 1 | |
| 28 | 595-0275-1 | Decal, PTO Rewind | 1 |
Page 39
| Numerical Parts Listing | ||||
| Page | ||||
| No. | Part Number | Description | Qty. | |
| 28 | 595-0275-2 | Decal, Anti-Return Pawl | 1 | |
| 26 | 595-0382-0 | Hub & Axle Assy. Complete ( Not Shown ) | 1 | |
| 24 | 595-0482-1 | Tach Pulley 1.64 | 1 | |
| 2 | 595-0483-0 | Pin, Hitch 5.75" x 3/4" | 1 | |
| 28 | 595-0501-0 | Decal, Important (Engine) | 1 | |
| 26 | 595-0606-0 | Wheel & Tire Assembly | 1 | |
| 6 | 596-0014-0 | Spacer | 1 | |
| 28 | 596-0017-0 | Decal, Supply Hose | 1 | |
| 26 | 596-0137-0 | Spindle | 2 | |
| 28 | 596-0309-0 | Decal, Brake Adj. (Not Shown) | 1 | |
| 28 | 596-0426-0 | Decal, Change Oil | 1 | |
| 28 | 596-0428-0 | Decal, Lub. (Not Shown) | 1 | |
| 28 | 597-0055-0 | Decal, Warning Read Operator Manual | 1 | |
| 4 | 597-0119-1 | Operator Manual Holder | 1 | |
| 26 | 597-0312-0 | Cap, Guncart | 1 | |
| 30 | 598-0141-1 | Engine, Robin 4HP | 1 | |
| 30 | 599-0026-1 | Backing Plate | 1 | |
| 30 | 599-0027-0 | Swivel | 1 | |
| 30 | 599-0028-0 | Throttle Link | 1 | |
| 30 | 599-0034-0 | Link Shut Off | 1 | |
| 30 | 599-0035-0 | Throttle Pivot Arm | 1 | |
| 30 | 599-0039-0 | Throttle Brkt. 30A | 1 | |
| 30 | 599-0041-0 | Switch Arm 30A | 1 | |
| 30 | 599-0042-0 | Slide, Switch | 1 | |
| 30 | 599-0043-0 | Switch Ramp | 1 | |
| 4 | 599-0064-0 | Operator Manual Bracket ( Not Shown ) | 1 | |
| 30 | 599-0066-0 | Throttle Mount | 1 | |
| 30 | 599-0075-1 | Entry Fitting 30A | 1 | |
| 30 | 599-0075-2 | Entry Fitting 33A | 1 | |
| 30 | 599-0084-0 | Pulley, 3 Step 2"-3"-4" 3/4" Bore | 1 | |
| 30 | 599-0132-0 | Throttle Control Cable | 1 | |
| 20 | 599-0146-0 | Gauge Protector | 1 | |
| 20 | 599-0148-0 | Gauge Mount | 1 | |
| 30 | 599-0194-0 | Cradle Plate | 1 | |
| 30 | 599-0219-1 | Fuel Tank 4 HP Robin | 1 | |
| 30 | 599-0221-0 | Cap, Robin | 1 | |
| 30 | 599-0221-1 | Cap, Honda | 1 | |
| 30 | 599-0253-0 | Jackshaft Mount | 1 | |
| 30 | 599-0255-2 | Engine Mount 30A | 1 | |
| 30 | 599-0265-0 | Spring Holder | 1 | |
| 30 | 599-0277-0 | Jack Shaft | 1 | |
| 30 | 599-0324-0 | Wire Harness | 1 | |
| 30 | 599-0325-0 | Connector | 1 | |
| 30 | 599-0424-0 | Strap | 1 | |
| 30 | 599-0429-0 | Strap | 1 | |
| 30 | 599-0430-0 | Switch Contact | 1 | |
| 30 | 599-0432-0 | Plate | 1 |
Page 40
| Numerical Parts Listing | ||||
| Page | ||||
| No. | Part Number | Description | Qty. | |
| 30 | 599-0279-0 | Switch, Robin Shut Off | 1 | |
| 30 | 599-0293-0 | Pulley 2" 3/4" Bore | 1 | |
| 30 | 599-0297-1 | Plate, 30A | 1 | |
| 30 | 599-0323-0 | Shield | 1 | |
| 30 | 599-0324-0 | Wire Harness A Series | 1 | |
| 30 | 599-0338-0 | Bearing, 2 Hole Flange ( Cast Iron Housing ) | 2 | |
| 30 | 599-0341-0 | Pulley, 3" x 3/4" Bore | 2 | |
| 30 | 599-0343-0 | Belt, AX 42 | 1 | |
| 30 | 599-0344-0 | Switch Holder | 1 | |
| 28 | 599-0369-0 | Decal, Performance Guide 30A | 1 | |
| 28 | 599-0370-0 | Decal, Performance Guide 33A | 1 | |
| 26 | 599-0417-0 | Body, Guncart Without Shut Off Bar | 1 | |
| 30 | 599-0422-0 | Spring, .045"w x .38 OD x 2.5" Long | 1 | |
| 30 | 599-0443-0 | Fuel Tank 8 HP Honda | 1 | |
| 12 | 750-4844-0 | Cable, 1/4 - 7 X 19 Galv. | FT. | 10 |
| 26 | 850-4059-0 | Chain 3/16" Proof Coil ( Per Foot ) ( 10 Links ) | FT. | |
| 26 | 850-4060-0 | Chain 3/8 Proof Coil | FT. | 3 |
Copyright © 2000, Kifco